traction daily cleaner /degreaser

TRACTION
DAILY CLEANER
MATERIAL SAFETY DATA SHEET
This MSDS complies with OSHA'S Hazard Communication Standard 29 CFR 1910.1200 and OSHA Form 174
/DEGREASER
IDENTITY AND DISTRIBUTOR'S INFORMATION
NFPA Rating: Health-1; Flammability-0; Reactivity-0; Special- Manufactured For: SURE GRIP FLOOR SYSTEMS, INC.
Address: 2801-3 Capital Circle NE Tallahassee, Florida 32308
Phone: 1-800-928-6281
Emergency Response Number: 1-800-424-9300
NOTICE: JUDGEMENT BASED ON INDIRECT TEST DATA
HMIS Rating: Health-1; Flammability-0; Reactivity-0; Personal Protection-B
DOT Hazard Classification: NON-REGULATED
Identity (trade name as used on label):
SURE GRIP DAILY CLEANER / DEGREASER
MSDS Number:
B07148 Revision – 1
Date Prepared: 07/01/09
Prepared By:
IB
Information Calls:
(770) 422-2071
TRACTION
DAILY CLEANER
/DEGREASER
SECTION 1 - MATERIAL IDENTIFICATION AND INFORMATION
COMPONENTS-CHEMICAL NAMES AND COMMON NAMES
(Hazardous Components 1% or greater; Carcinogens 0.1% or greater)
DODECYLBENZENE SULFONIC ACID
HYDROXYACETIC ACID
CAS Number
27176-87-0
79-14-1
SARA
III LIST
No
No
OSHA PEL
(ppm)
NE
NE
ACGIH
TLV (ppm)
NE
NE
Carcinogen
Ref. Source **
d
d
SECTION 2 - PHYSICAL/CHEMICAL CHARACTERISTICS
Boiling Point:
Vapor Pressure:
Vapor Density (Air = 1):
Solubility in Water:
Appearance and Odor:
212ºF
PSIG @ 70°F (Aerosols): N/A
N/D
Miscible
Water based clear, green liquid with citrus odor.
Specific Gravity (H2O=1):
1.04
Vapor Pressure (Non-Aerosols) (mm Hg and Temperature): N/D
Evaporation Rate ( water = 1):
approximately 1
Water Reactive:
No
SureGrip Daily Cleaner / Degreaser is the first
line of defense in the battle against slippery floors.
Unlike most cleaner-degreasers, it is alkaline free.
Alkaline cleaners leave residue behind and will turn
a wet floor into a serious slip hazard. Our Daily
Cleaner / Degreaser emulsifies and suspends oil,
grease and other contaminates, lifting from deep
in the microscopic pores of the floor surface. Once
the grease is emulsified, it can easily be extracted
or rinsed away leaving the floor surface residuefree. When SureGrip Cleaner / Degreaser is used
daily it will reduce the occurrence of polymerization,
greatly improving surface traction.
SECTION 3 - FIRE AND EXPLOSION HAZARD DATA
FLAMMABILITY as per USA FLAME PROJECTION TEST
(aerosols) N/A
FLASH POINT AND METHOD USED (non-aerosols): None to boiling (TCC)
SPECIAL FIRE FIGHTING PROCEDURES: None.
Unusual Fire & Explosion Hazards: None
Auto Ignition Temperature
Flammability Limits in Air by % in Volume:
N/A
% LEL: N/A % UEL: N/A
EXTINGUISHER MEDIA: Non-combustible. Use media compatible with
surrounding fire.
SECTION 4 - REACTIVITY HAZARD DATA
STABILITY [ X ] STABLE [ ] UNSTABLE
HAZARDOUS POLYMERIZATION [ ] WILL [ X ] WILL NOT OCCUR
Incompatibility (Mat. to avoid): Stong oxidizers.
Conditions to Avoid: None known.
Hazardous Decomposition Products: Oxides of carbon, nitrogen, sulfur & other unidentified organic compounds.
SECTION 5 - HEALTH HAZARD DATA
PRIMARY ROUTES OF ENTRY: [ ] INHALATION [ X ] INGESTION [ X ] SKIN ABSORPTION [ X ] EYE [ ] NOT HAZARDOUS
ACUTE EFFECTS:
Inhalation:
Eye Contact:
Skin Contact:
Ingestion:
CHRONIC EFFECTS:
Medical Conditions Generally Aggravated by Exposure:
Product is not volatile. Inhalation of product vapor unlikely.
Irritant.
Irritant.
Irritating. May cause nausea, vomiting or diarrhea.
None known.
Any irritated tissue present may be further irritated by repeated or prolonged exposure.
EMERGENCY FIRST AID PROCEDURES
Eye Contact:
Skin Contact:
Inhalation:
Ingestion:
Flush with water for 15 minutes. If irritation persists, get medical attention.
Remove contaminated clothing. Wash with soap and warm water. If irritation persists, get medical attention.
Remove to fresh air.
DO NOT INDUCE VOMITING. Drink 2 glasses of water and call for medical advisal.
SECTION 6 - CONTROL AND PROTECTIVE MEASURES
Respiratory Protection (specify type):
Protective Gloves:
Eye Protection:
Ventilation Requirements:
Other Protective Clothing & Equipment:
Hygienic Work Practices:
None required. Particulate mask recommended if product application yields a fine particle mist that suspends in the air.
Rubber or nitrile, if desired.
Safety glasses or goggles as appropriate.
None required.
Readily accessible fresh water or potable water source that provides a gentle irrigation of ambient or cool temperature water for
flushing eyes.
Do not eat, drink or smoke in work area. Wash hands after handling.
SECTION 7 - PRECAUTIONS FOR SAFE HANDLING AND USE
Steps To Be Taken If Material Is Spilled Or Released:
Waste Disposal Methods:
Precautions To Be Taken In Handling & Storage:
Other Precautions &/or Special Hazards:
Soak up in absorbent material & seal in properly labeled non-leaking containers for proper authorized waste disposal.
Dispose of in accordance with all local, state and federal regulations.
Store in original shipping containers. Keep closed when not in use. Protect from freezing.
KEEP OUT OF REACH OF CHILDREN. Read & follow label directions.
We believe the statements, technical information and recommendations contained herein are reliable, but they are given without warranty or guarantee of any kind.
** Chemical Listed as Carcinogen or Potential Carcinogen. [a] NTP [b] IARC Monograph [c] OSHA [d] Not Listed [e] Animal Data Only
Recommended uses:
All flooring including:
Walls
Slate Ceramic
Saltillo Quarry
Equipment
Recycled PVC Terrazzo
Concrete Wood
VCT
Dilution Ratios
Mop Bucket
Daily Maintenance: 2oz.per Gallon (1:64)
Heavy Soil: 4oz. per Gallon (1:32)
Data
Appearance:
Odor:
DOT Hazardous ingredients:
Vapor pressure (mm/hg):
Boiling point, F:
Solubility in water:
Flash Point:
Alkaline Free – No Slippery Residue
Effectively Emulsifies Grease
Contains no Phosphates, Butyl or Bleaches
Cost Effective
NSF Registered and Approved
Foam Gun
Daily Maintenance: 4 oz. per Gallon (1:32)
Green liquid
Fresh
None
17mm @ 20 C
212 F (ASTM D-1120)
Complete
>101C (ASTM D-56) Tag closed cup
(800) 928.6281
Making the world a safer place ...one step at a time! www.SureGripFloors.com
FRONT
OF HOUSE FLOOR CLEANING PROCEDURES
Instrucciones para el Mantenimiento Diario del Frente
1. Always place signs in highly
2. Thoroughly sweep all debris
3. Fill mop bucket with
Coloque siempre señales en las
zonas visibles advirtiendo a las
personas de que los suelos están
mojados y podrían ser resbaladizos.
Recoja todos los residuos del piso
con una escoba y retírelos.
Llene una cubeta con el limpiador
Limpiador Diario SureGrip®.
Mezcle de acuerdo a la etiqueta o
utilice un sistema de dosificación.
4. For high traffic areas, liberally
5. Using a deck brush quickly,
6. Mop area with tightly wrung
Para zonas alto tráfico, limpie
abundantemente con la solución en
un área de tamaño medio y continúe
con el paso número 5. Para áreas
sin tráfico, pase al número 6.
Utilizando un cepillo, limpie
rápidamente fregando a fondo todas
las áreas de mayor tráfico,
especialmente aquellas que están
mas cercanas a la cocina.
Friegue la zona con una mopa bien
escurrida. Continúe hasta que todo
el suelo esté bien limpio. Cambie la
solución en la cubeta cuando se
ponga visiblemente sucia.
visible areas warning people that
the floors are wet and could be
slippery.
mop on solution to a medium sized
area and then proceed to step #5.
For non-high traffic areas, proceed
to step #6
from floor surface and remove.
but thoroughly scrub all high traffic
areas, especially those next to the
kitchen.
SureGrip® Traction enhancing Daily
Cleaner. Always mix according to
the label or use a proportioning
system.
out mop. Continue process until
entire floor is clean. Change solution
in mop bucket when it becomes
visibly dirty.
Please visit www.SureGripFloors.com
for a collection of Floor Cleaning Procedures and Training Material!
KITCHEN
FLOOR CLEANING PROCEDURES
Instrucciones para el Mantenimiento Diario de la Cocina
1. Always place signs in highly
visible areas warning people that
the floors are wet and could be
slippery.
Coloque siempre señales en zonas
muy visibles advirtiendo a las
personas de que los suelos están
mojados y podrían ser resbaladizos.
4. Using a deck brush quickly,
but thoroughly scrub area.
Utilizando un cepillo, limpie rápido
pero a fondo la zona a limpiar.
2. Thoroughly sweep all debris
3. Fill foam gun with SureGrip®
Barra todos los residuos del piso y
retírelos.
Llene la pistola de espuma con el
Limpiador Diario SureGrip® y fíjela
a la manguera de agua. Aplique
abundante espuma en todas las
áreas del suelo.
5. Rinse floor with clean water.
6. Squeegee water down drain
Enjuague el suelo con agua limpia.
Pase el ecurridor hacia el desagüe
y deje que se seque el suelo.
from floor surface and remove.
Daily Cleaner and attach gun to
water hose. Liberally apply foam to
all floor areas.
and allow floor to dry.
CLEAN FLOORS = SAFE FLOORS
Making the world a safer place …one step at a time.
For more information call 1-800-928-6281 or visit our website at www.suregripfloors.com
Para mas información llámenos 1-800-928-6281 o visite nuestra website www.suregripfloors.com