CERO DESCARGAS INDUSTRIALES La actividad industrial se ha asentado por obvias razones en los márgenes de los ríos, lagos, esteros y orillas de los mares, esto por la necesidad de grandes cantidades de agua, ya sea para sus procesos específicos o para sus sistemas de enfriamiento. En los últimos años la escasez y el costo, se ha recurrido a utilizar el agua de los mantos freáticos, ya sea de acuíferos fosilisados o de recarga, esto dependiendo de la geología del suelo y sus características geomorfológicas. Históricamente hemos utilizado a los ríos, lagos y mares como vertederos en donde se recoge, desde tiempos inmemoriales, las basuras producidas por la actividad humana. El ciclo natural del agua tiene una gran capacidad para su purificación. Pero esta misma facilidad de regeneración del agua, y su aparente abundancia, hace que sea el vertedero habitual en el que arrojamos residuos como pesticidas altamente tóxicos, metales pesados, desechos químicos, residuos radiactivos, entre otros, algunos se encuentran, en cantidades mayores o menores, y concentraciones que es imposible que la naturaleza purifique esta agua en un tiempo a mediano plazo, los análisis de de los cuerpos de agua, tanto superficiales como subterráneos de los más remotos lugares del mundo, se encuentran contaminados a tan elevado nivel en cantidad y concentración que los hace peligrosos para la salud humana, y altamente riesgosos para los ecosistemas de lagos, ríos, esteros e inclusive en las desembocaduras de los ríos en los océanos. Cuando existe un ordenamiento territorial en los países, en donde el uso del suelo esta bien definido; habitacional, agropecuario e industrial, se pueden controlar de una mejor forma las descargas de los procesos. Mientras que en los países en donde no se cumple con este ordenamiento y las leyes del uso y manejo de las aguas, el problema se presenta caótico. Cuando las diferentes características de los procesos de las industrias; Metal Mecánica, Química, Tenerías, Textil, Electrónica, Automotriz, Alimenticia, entre otras, no están ordenadas en polígonos industriales de acuerdo a sus diferentes actividades, en donde se presentan problemáticas similares de sus contaminantes residuales, estos dañan tanto en suelo, aire y agua. El problema de contaminación de los cuerpos de agua por metales pesados, es principalmente por las actividades de la industria, en los países subdesarrollado, en donde han llegado a colapsar por sus altos niveles de contaminación. En un país como México, en donde no se respeta el uso del suelo y no se cumple o hace cumplir la ley, se presenta un total desorden en las industrias a nivel nacional, descargan en los cauces volumen de miles de toneladas al año de contaminantes de todo tipo, que han convertido sus cuerpos de agua en sucias cloacas, cargadas de productos químicos, espumas y toda clase de contaminantes. Cuando hablamos de metales pesados, nos referimos a elementos químicos que tienen un peso atómico entre 63.55 (del cobre Cu) y 200.59 (del mercurio Hg), y con un peso específico superior a 4 g/cm3. En general las características esenciales de estos metales no los hace tóxicos, pero sí su concentración y reacción en el agua o en los seres vivos. Los límites de toxicidad se determina para ríos y lagos, y en esteros o agua salada, la Agencia de Protección Ambiental (EPA) de los Estados Unidos ha determinado los límites de las concentraciones de metales pesados, al rebasar dichos parámetros, los metales pesados pueden causar graves trastornos a los seres vivos e inclusive la muerte. Los organismos acuáticos que son afectados por pequeñas concentraciones de metales pesados presentan problemas fisiológicos y metabólicos como; Cambios histológicos y morfológicos en los tejidos, cambio en la fisiología como supresión del crecimiento y desarrollo (torpeza para nadar), cambio en la bioquímica del organismo (química de la sangre) Trastorno del comportamiento, Cambios en la reproducción, entre otros, a estas pequeñas concentraciones se le considera una dosis subletal y a un nivel mayor se considera mortal. Cuando el hombre o la cadena alimentaría ingesta estos peces pasan directamente a los organismos consumidores, pudiendo presentar los mismos cuadros fisiológicos y metabólicos. En México la Norma Oficial Mexicana publicada en el diario oficial del 18 de octubre de 1993, contra la contaminación ambiental consideran metales pesados contaminantes por su abundancia, en los cuerpos de agua; Aluminio, Plata, Cadmio, Arsénico, Cobre, Fierro, Mercurio, Cobalto, Vanadio, Manganeso, Níquel, Zinc, Magnesio, Antimonio, Cromo, Selenio, Titanio, Berilio, Estaño, Boro, Molibdeno, Tungsteno, Germanio, Bismuto, Plomo y Telurio. Los estudios que hemos realizado en el Lago de Chapala, de la calidad del agua nos han demostrado grandes cantidades de plomo, cadmio, mercurio, zinc, arsénico mercurio, entre otros. Los metales pesados solubles en agua como el plomo, cadmio y mercurio son muy tóxicos y acumulables por los organismos que las absorben o quien los ingiere, los problemas de salud que provoca en el hombre es; ceguera, amnesia, raquitismo, miastenia o hasta la muerte. Cuando un sistema de gobierno se ve imposibilitado para hacer cumplir la ley y evitar que existan miles de toneladas de contaminantes vertidas a los ríos, lagos, esteros, océanos o inclusive re inyectando a los mantos acuíferos, todo este material tóxico producto de los procesos industriales, que en una parte importante son de empresas trasnacionales y que en su país son prohibidos los procesos por ser tecnologías que no cumplen con las normas internacionales. También existe la incapacidad o quizás la corrupción en la vigilancia de la autoridad. ¿Que Hacer? Crear los sistemas de Cero Descargas Industriales, que consiste en utilizar el agua en sistemas cerrados, en donde se recircula el agua y se tratara de acuerdo al proceso, y en donde nunca se mandan los caudales que ingresaron al proceso a los cuerpos de agua. Cuando los procesos de manufactura de la industria generan vapor que no es aprovechado, entonces los caudales se remplazan. El sistema será analizado para poder determinar el costo beneficio del diseño. En ocasiones se abastece a las industrias a través de los sistemas de agua potable con costos bastante elevados y estos caudales deberán ser tratados para poderlos utilizar en los procesos de acuerdo a las especificaciones de cada industria. Importante será realizar los polígonos industriales con Cero Descargas, ya que los tratamientos serán controlados y todas las descargas individuales monitoreadas, pudiendo realizar un adecuado tratamiento e inclusive podrán existir casos de recuperación de elementos de alto valor industrial. Dr. José Antonio Gómez Reyna Comité Científico Global Nature Fund —Living Lakes ZERO INDUSTRIAL DISCHARGES The industrial activity has settled for obvious reasons in the margins of the rivers, lakes, tidelands and banks of the seas, this for the necessity of big quantities of water, either for its specific processes or it stops its cooling systems. In the last years the shortage and the cost, it has been appealed to use the water of the phreatic mantels, either of aquifer fosilisados or of recharge, this depending on the geology of the floor and their characteristic geomorfológicas. Historically we have used to the rivers, lakes and seas like drains where it is picked up, from immemorial times, the garbages taken place by the human activity. The natural cycle of the water has a great capacity for its purification. But this same easiness of regeneration of the water, and its apparent abundance, makes that it is the habitual drain in which throw residuals like highly toxic pesticides, heavy metals, chemical waste, radioactive residuals, among other, some are, in bigger or smaller quantities, and concentrations that it is impossible that the nature purifies this water at one time to medium term, the analyses of of the bodies of water, so much superficial as undergrounds of the most remote places in the world, they are polluted at so high level in quantity and concentration that he/she makes them dangerous for the human, and highly risky health for the ecosystems of lakes, rivers, tidelands and inclusive in the outlets of the rivers in the oceans. When a territorial classification exists in the countries where the use of the floor this very defined one; residence, agricultural and industrial, they can be controlled in a better way the discharges of the processes. While in the countries where it is not fulfilled this classification and the laws of the use and handling of the waters, the problem is presented chaotic. When the different characteristics of the processes of the industries; Metal Mechanics, Chemistry, Tanneries, Textile, Electronic, Self-driven, Nutritious, among other, they are not orderly in industrial polygons according to their different activities where are presented problematic similar of their residual pollutants, these they damage so much in floor, air and it dilutes. The problem of contamination of the bodies of water for heavy metals, is mainly for the activities of the industry, in the underdeveloped countries where have ended up collapsing for its high levels of contamination. In a country like Mexico where the use of the floor is not respected and it is not completed or he/she makes complete the law, a total disorder is presented in the industries at national level, they discharge in the beds volume of thousands of tons to the year of pollutants of all type that you/they have transformed its bodies of water into dirty sewers, loaded with chemical products, foams and all kinds of pollutants. When we speak of heavy metals, we refer to chemical elements that have an atomic weight among 63.55 (of the copper Cu) and 200.59 (of the mercury Hg), and with a weight specific superior to 4 g/cm3. In general the essential characteristics of these metals don't make them toxic, but yes their concentration and reaction in the water or in the alive beings. The toxicity limits are determined for rivers and lakes, and in tidelands or salted water, the Agency of Environmental Protection (EPA) of the United States it has determined the limits of the concentrations of heavy metals, when surpassing this parameters, the heavy metals can cause serious dysfunctions to the alive beings and inclusive the death. The aquatic organisms that are affected by small concentrations of heavy metals present physiologic and metabolic problems as; Changes histológicos and morphological in the fabrics, change in the physiology like suppression of the growth and development (stupidity to swim), I change in the biochemistry of the organism (chemistry of the blood) I Overturn of the behavior, Changes in the reproduction, among other, to these small concentrations are considered a dose subletal and at a bigger level it is considered human. When the man or the chain would feed ingesta these fish they pass directly to the organisms consumers, being able to present the same physiologic and metabolic squares. In Mexico the Mexican Norma Official published in the official newspaper of October of 1993, 18 against the environmental contamination considers metals heavy pollutants for her abundance, in the bodies of water; Aluminum, Silver, Cadmium, Arsenic, Copper, Iron, Mercury, Cobalt, Vanadium, Manganese, Nickel, Zinc, Magnesium, Antimony, Chromium, Selenium, Titanium, Berilio, Tin, Boron, Molybdenum, Tungsten, Germanium, Bismuth, Lead and Tellurium. The studies that we have carried out in the Lake of you Plate it, of the quality of the water they have demonstrated us big quantities of lead, cadmium, mercury, zinc, arsenic mercury, among others. The soluble heavy metals in water as the lead, cadmium and mercury are very toxic and cumulative for the organisms that absorb them or who ingests them, the problems of health that it causes in the man are; blindness, amnesia, rachitis, miastenia or until the death. When government's system is helpless to make to complete the law and to avoid that thousands of tons of pollutants poured to the rivers exist, lakes, tidelands, oceans or inclusive re injecting to the aquifer mantels, this whole material toxic product of the industrial processes that you/they are of transnational companies in an important part and that in its country the processes are prohibited to be technologies that don't fulfill the international norms. The inability also exists or maybe the corruption in the surveillance of the authority. What to do? To create the systems of Zero Industrial Discharges that it consists on using the water in closed systems where the water is recycled and it was according to the process, and where the flows are never sent that entered to the process to the bodies of water. When the processes of factory of the industry generate vapor that is not taken advantage of, then the flows you remplazan. The system will be analyzed to be able to determine the cost benefit of the design. In occasions it is supplied to the industries through the systems of drinkable water with quite high costs and these flows will be treated to be able to them to use in the processes according to the specifications of each industry. Important it will be to carry out the industrial polygons with Zero Discharges, since the treatments will be controlled and all the discharges individual monitoreadas, being able to carry out an appropriate treatment and inclusive they will be able to exist cases of recovery of elements of high industrial value. Dr. José Antonio Gómez Reyna Scientific committee Global Nature Fund - Living Lakes